Product ID:00-014 TACKLE
MSDS Date:02/25/1988
FSC:6850
NIIN:00F038413
MSDS Number: BYJBH

CRAWFORD LABORATORIES INC

4165 S EMERALD AVE
CHICAGO, IL 60609-2646
US

Emergency Phone: 312-433-1307/312-376-7132

Info Phone: 312-376-7132/312-433-1307

Cage: DO165

CRAWFORD LABORATORIES, INC

CHICAGO, IL 60609 US

Telephone: 312-376-7132

Cage: 5V430

SODIUM METASILICATE; SODIUM SILICATE; WATER GLASS; DISODIUM

CAS: 6834-92-0

RTECS: VV9275000

Fraction By Weight: 1-5%

2-BUTOXYETHANOL (ETHYLENE GLYCOL MONOBUTYL ETHER), BUTYL

CAS: 111-76-2

RTECS: KJ8575000

Fraction By Weight: 1-5%

OSHA PEL 50 PPM (SKIN)

ACGIH TLV: 25 PPM (SKIN)

Routes of Entry: Inhalation:NO Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:SKIN/EYES: BURNS. INHALATION:
IRRITATION OF THE MUCOUS MEMBRANES.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:BURNS, HEADACHE, DIZZINESS, DEFATTING, DRYING,
IRRITATION.

First Aid:EYES: FLUSH W/WATER. DON'T ATTEMPT TO NEUTRALIZE THE ACID
W/CHEMICALS, OIL/OINTMENTS, UNLESS INSTRUCTED BY A PHYSICIAN.
INHALATION: REMOVE TO FRESH AIR. GIVE CPR/OXYGEN IF NEEDED. KEEP
WARM & COMFORTA BLE. NEVER GIVE LIQUIDS TO AN UNCONSCIOUSPERSON.
INGESTION: DON'T INDUCE VOMITING. IF CONSCIOUS/ALERT GIVE LUKEWARM
WATER/MILK. IF AVAILABLE, GIVE MILK OF MAGNESIA ( 20 ML). (SEE
SUPP)

Flash Point Method:SCC
Flash Point:141F
Lower Limits:1.1
Extinguishing Media:FOAM, CO2/DRY CHEMICAL
Fire Fighting Procedures:WATER MAY BE USED TO KEEP CONTAINERS COOL.
DON'T ENTER W/O PROPER PROTECTION. DON'T SPRAY DIRECTLY. WATER
PRESSURE MAY SPREAD A FLAMMABLE LIQUID FIRE.
Unusual Fire/Explosion Hazard:SEALED CONTAINERS MAY EXPLODE IF
OVERHEATED. PRODUCT CONTAINS SOME ACIDS, WHICH REACTS W/METALS TO
PRODUCE HYDROGEN. A FLAMMABLE GAS.

Spill Release Procedures:COMBUSTIBLE. ELIMINATE IGNITION SOURCES.
HANDLING EQUIPMENT MUST BE GROUNDED TO PREVENT SPARKING. WEAR
PROTECTIVE CLOTHING. SOAK UP W/ABSORBENT & PLACE IN NON-LEAKING
CONTAINERS. SEAL TIGHTLY FOR PROP ER DISPOSAL.

Handling and Storage Precautions:TREAT AS ANY HAZARDOUS COMBUSTIBLE
MATERIAL. STORE IN A COOL, DRY PLACE IN BUILDINGS DESIGNED FOR THE
STORAGE OF COMBUSTIBLE LIQUIDS.

Respiratory Protection:USE NIOSH APPROVED ORGANIC VAPOR RESPIRATORS
WHERE VENTILATION IS INADEQUATE.
Ventilation:USE ADEQUATE VENTILATION TO MAINTAIN VAPOR CONCENTRATIONS
BELOW TLV LIMIT.
Protective Gloves:IMPERVIOUS RUBBER
Eye Protection:CHEMICAL SAFETY SPLASH GLASSES
Other Protective Equipment:EYE BATH, SAFETY SHOWER
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING & SHOES
BEFORE REUSE.
Supplemental Safety and Health
HEALTH HAZARDS CONT'D: IF VOMITING, AFTER ADMINISTERING FLUIDS,
ADMINISTER FLUIDS AGAIN. GIVE DEMULCENTS, SUCH AS MILK/BEATEN EGGS,
AT INTERVALS OF 1-2 HOURS. NEVER GIVE ANYTHING BY MOUTH TO AN
UNCONS CIOUS PERSON. SKIN: WASH W/WATER. DON'TATTEMPT TO NEUTRALIZE
W/CHEMICAL AGENTS. OBTAIN MEDICAL ATTENTION IN ALL CASES.

Boiling Pt:B.P. Text:212-340F
Vapor Density:>1
Evaporation Rate & Reference:(N-BU AC =1): 0.09
Appearance and Odor:CLEAR THICK LIQUID
Percent Volatiles by Volume:3.4

Stability Indicator/Materials to Avoid:YES
ALUMINUM, LEATHER, WOOL, TIN, ZINC, ALLOYS CONTAINING THESE MATERIALS.
REACTS W/ALKALIES (BASES).
Stability Condition to Avoid:HEAT, SPARKS, OPEN FLAMES, INCOMPATIBLES.
Hazardous Decomposition Products:COMBUSTION: HYDROGEN GAS. INCOMPLETE
COMBUSTION: HIGHLY POISONOUS CO & OTHER TOXIC GASES.

Waste Disposal Methods:DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS. CONTACT AN APPROVED DISPOSAL FACILITY.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.